Toughened safety glass in Edinburgh

How much does toughened safety glass cost in Edinburgh?

Guide prices for toughened safety glass in Edinburgh are £114 to £414 including VAT (£95 to £345 plus VAT) per pane for supply and fitting. We confirm a fixed price in writing after a free survey, before any glass is ordered.

Toughened safety glass is ordinary glass that has been heated and rapidly cooled so its surface is held in compression, making it four to five times stronger than annealed glass of the same thickness. If it does break, it shatters into small, relatively blunt pieces instead of sharp shards, which is why it is used in doors, low-level panes and frameless partitions.

What you can specify

Single panes or the outer pane of a sealed unit
Four to five times the strength of annealed glass
Made to measure for each opening
Holes, notches and polished edges for frameless fittings
Heat-soaked option for large and overhead panes
Made to BS EN 12150 and marked for identification

Fitting in Edinburgh and nearby

We arrange surveys and fitting across Edinburgh and the EH1 postcode district, and in nearby Musselburgh (6 miles), Dalkeith (6 miles) and Penicuik.

Windows and shopfronts in Edinburgh's World Heritage centre are closely controlled, while Livingston, Musselburgh and the other Lothian towns have newer estates, offices and retail parks.

Typical places for toughened safety glass:

Panes below 800 mm in homes and offices
Shower screens and splashbacks
Frameless office partitions and doors
Glazed doors and side panels

Things to decide before you order

Heat soaking

Rare nickel sulphide inclusions can make toughened glass break without warning. Heat soaking reduces the risk and is worth specifying for large, high or overhead panes.

Measure once, carefully

Toughened glass cannot be cut afterwards, so holes and sizes are fixed at the factory. Accurate survey measurements avoid remakes.

Rules that apply in Scotland

Scotland

Safety glass in critical locations

In Scotland, standard 4.8 of the Building Standards technical handbooks covers glazing at risk of human impact. Panes within 800 mm of floor level, in a door leaf, or within 300 mm of a door leaf and up to 1.5 m above the floor should resist impact in line with BS 6262-4, or be guarded. Laminated and toughened glass are the usual ways to meet it.

Glazing in workplaces

Regulation 14 of the Workplace (Health, Safety and Welfare) Regulations 1992 applies in Scotland. Windows and transparent surfaces in walls, partitions, doors and gates must be of safety material or protected against breakage where health or safety requires it, and marked so people see them. The duty holder's risk assessment decides where.

How it works

Guide price online or by phone
Survey in Edinburgh
Accept the fixed quote
Fitted by glaziers working under our contract

Toughened safety glass in Edinburgh: questions

Do you cover Musselburgh as well as Edinburgh?

Yes. As well as Edinburgh, we can arrange surveys in nearby Musselburgh, Dalkeith and Penicuik. Dates depend on installer availability.

Can toughened glass be cut to fit?

No. Cutting or drilling toughened glass makes it shatter, so every pane, hole and notch is made to size before toughening.

How can I tell if glass is toughened?

Look for a permanent mark etched in a corner naming the standard. Polarised sunglasses can also show faint patterns in toughened glass. We can check during the survey.

Why did my toughened glass break on its own?

Occasionally a tiny nickel sulphide inclusion or edge damage causes spontaneous breakage. Heat-soak tested glass reduces the risk for large or high panes.

Toughened safety glass in nearby towns

Other glazing in Edinburgh

Tell us about the glazing and we will come back with a guide price.