Toughened safety glass in Stonehaven: what will it cost?
Typical prices for toughened safety glass in Stonehaven are £114 to £414 including VAT (£95 to £345 plus VAT) per pane, supplied and fitted. Use the quote tool for a guide figure, then we survey and confirm a fixed price.
Toughened safety glass is ordinary glass that has been heated and rapidly cooled so its surface is held in compression, making it four to five times stronger than annealed glass of the same thickness. If it does break, it shatters into small, relatively blunt pieces instead of sharp shards, which is why it is used in doors, low-level panes and frameless partitions.
Choices you can make
- Made to measure for each opening
- Clear, tinted, obscure, low-iron and sandblasted finishes
- Breaks into small blunt fragments
- Single panes or the outer pane of a sealed unit
- Heat-soaked option for large and overhead panes
- Made to BS EN 12150 and marked for identification
Fitting in Stonehaven and nearby
We can arrange toughened safety glass anywhere in Stonehaven, and in nearby Aberdeen, Montrose and Inverurie. Tell us your postcode and we will offer dates.
This area runs from Aberdeen's granite city-centre offices and shops to Aberdeenshire towns such as Inverurie and Peterhead and Elgin in Moray, with hard North Sea weather on the coast.
Typical settings for toughened safety glass:
- Glazed doors and side panels
- Shower screens and splashbacks
- Frameless office partitions and doors
- Balustrades in a laminated toughened makeup
Getting the right glass for your building
Toughened or laminated
Toughened gives strength and safe breakage. Laminated gives safe breakage and stays in place, which is what security needs. Many doors use both in one sealed unit.
Barriers and balustrades
Glass that acts as a barrier usually needs a laminated toughened makeup so it stays in place if one ply breaks.
What the rules say in Scotland
Glazing in workplaces
Regulation 14 of the Workplace (Health, Safety and Welfare) Regulations 1992 applies in Scotland. Windows and transparent surfaces in walls, partitions, doors and gates must be of safety material or protected against breakage where health or safety requires it, and marked so people see them. The duty holder's risk assessment decides where.
Fire-rated glass is different
Glass in fire doors and fire screens must be fire-rated glass tested within that system, under section 2 of the Building Standards technical handbooks and the Fire (Scotland) Act 2005 for non-domestic premises. Security and laminated glass are not fire-rated unless the product is tested for it.
How it works
- Send sizes or use the quote tool
- Free survey at your Stonehaven address
- Fixed price in writing
- Glass made, then fitted
Toughened safety glass in Stonehaven: questions
Which areas near Stonehaven do you cover?
We can arrange work in Stonehaven and in nearby Aberdeen (13 miles), Montrose (20 miles) and Inverurie (23 miles). Dates depend on installer availability.
Can toughened glass be cut to fit?
No. Cutting or drilling toughened glass makes it shatter, so every pane, hole and notch is made to size before toughening.
Is toughened glass a security glass?
No. Toughened glass is strong and breaks safely, but once broken the pane falls out and leaves the opening clear. For security, choose laminated glass or a unit with a laminated pane.
Where must safety glass be used?
In critical locations: in England, Approved Document K covers glazing in and beside doors up to 1,500 mm from the floor and other glazing below 800 mm; Wales has the same idea in its Approved Document N, Scotland in standard 4.8 and Northern Ireland in Part V. Glass there must be safety glass or protected.
Toughened safety glass in nearby towns
Other glazing in Stonehaven
- Security glazed doors and screens
- Security glass for doors
- Security window film
- Anti-bandit glass
- Broken glass replacement
- Bullet-resistant glass
Ready for a price? Use the form or call 0800 088 6248.