Toughened safety glass in Aberdeen

Toughened safety glass in Aberdeen: what will it cost?

Expect £114 to £414 including VAT (£95 to £345 plus VAT) per pane for toughened safety glass in Aberdeen. The written quote names the glass makeup, the price and the lead time before you commit.

Toughened safety glass is ordinary glass that has been heated and rapidly cooled so its surface is held in compression, making it four to five times stronger than annealed glass of the same thickness. If it does break, it shatters into small, relatively blunt pieces instead of sharp shards, which is why it is used in doors, low-level panes and frameless partitions.

What goes into toughened safety glass

Four to five times the strength of annealed glass
Clear, tinted, obscure, low-iron and sandblasted finishes
Breaks into small blunt fragments
Holes, notches and polished edges for frameless fittings
Made to measure for each opening
Made to BS EN 12150 and marked for identification

Fitting in Aberdeen and nearby

We arrange surveys and fitting in Aberdeen and across the AB10 postcode district. Tell us your postcode and we will offer dates.

This area runs from Aberdeen's granite city-centre offices and shops to Aberdeenshire towns such as Inverurie and Peterhead and Elgin in Moray, with hard North Sea weather on the coast.

Typical settings for toughened safety glass:

Panes below 800 mm in homes and offices
Shower screens and splashbacks
Frameless office partitions and doors
Balustrades in a laminated toughened makeup

Getting the right glass for your building

Heat soaking

Rare nickel sulphide inclusions can make toughened glass break without warning. Heat soaking reduces the risk and is worth specifying for large, high or overhead panes.

Measure once, carefully

Toughened glass cannot be cut afterwards, so holes and sizes are fixed at the factory. Accurate survey measurements avoid remakes.

What the rules say in Scotland

Scotland

Glazing in workplaces

Regulation 14 of the Workplace (Health, Safety and Welfare) Regulations 1992 applies in Scotland. Windows and transparent surfaces in walls, partitions, doors and gates must be of safety material or protected against breakage where health or safety requires it, and marked so people see them. The duty holder's risk assessment decides where.

Safety glass in critical locations

In Scotland, standard 4.8 of the Building Standards technical handbooks covers glazing at risk of human impact. Panes within 800 mm of floor level, in a door leaf, or within 300 mm of a door leaf and up to 1.5 m above the floor should resist impact in line with BS 6262-4, or be guarded. Laminated and toughened glass are the usual ways to meet it.

How it works

Send sizes or use the quote tool
Free survey at your Aberdeen address
Fixed price in writing
Glass made, then fitted

Toughened safety glass in Aberdeen: questions

Do you cover Stonehaven as well as Aberdeen?

Yes. As well as Aberdeen, we can arrange work in nearby Stonehaven. Dates depend on installer availability.

How can I tell if glass is toughened?

Look for a permanent mark etched in a corner naming the standard. Polarised sunglasses can also show faint patterns in toughened glass. We can check during the survey.

Is toughened glass a security glass?

No. Toughened glass is strong and breaks safely, but once broken the pane falls out and leaves the opening clear. For security, choose laminated glass or a unit with a laminated pane.

Where must safety glass be used?

In critical locations: in England, Approved Document K covers glazing in and beside doors up to 1,500 mm from the floor and other glazing below 800 mm; Wales has the same idea in its Approved Document N, Scotland in standard 4.8 and Northern Ireland in Part V. Glass there must be safety glass or protected.

Toughened safety glass in nearby towns

Other glazing in Aberdeen

Ready for a price? Use the form or call 0800 088 6248.