Toughened safety glass in Ashford, Surrey

What should toughened safety glass cost in Ashford, Surrey?

As a guide, allow £114 to £414 including VAT (£95 to £345 plus VAT) per pane for toughened safety glass in Ashford, Surrey, supplied and fitted. Size, glass makeup, access and frame condition move the price, which is confirmed in writing after the free survey.

Toughened safety glass is ordinary glass that has been heated and rapidly cooled so its surface is held in compression, making it four to five times stronger than annealed glass of the same thickness. If it does break, it shatters into small, relatively blunt pieces instead of sharp shards, which is why it is used in doors, low-level panes and frameless partitions.

What goes into toughened safety glass

Four to five times the strength of annealed glass
Holes, notches and polished edges for frameless fittings
Single panes or the outer pane of a sealed unit
Made to measure for each opening
Made to BS EN 12150 and marked for identification
Clear, tinted, obscure, low-iron and sandblasted finishes

Fitting in Ashford, Surrey and nearby

Surveys in Ashford, Surrey (TW15) are booked around installer availability. We also cover nearby Staines-upon-Thames (2 miles), Feltham (2 miles) and Sunbury-on-Thames (3 miles).

Surrey's commuter towns such as Guildford, Woking and Epsom mix Victorian and inter-war houses with modern glazed offices, while Farnham and Godalming have extensive conservation areas.

Good candidates for toughened safety glass:

Frameless office partitions and doors
Panes below 800 mm in homes and offices
Balustrades in a laminated toughened makeup
Glazed doors and side panels

Before the glass is ordered

Heat soaking

Rare nickel sulphide inclusions can make toughened glass break without warning. Heat soaking reduces the risk and is worth specifying for large, high or overhead panes.

Toughened or laminated

Toughened gives strength and safe breakage. Laminated gives safe breakage and stays in place, which is what security needs. Many doors use both in one sealed unit.

Glazing rules in England

England

Glazing in workplaces

Regulation 14 of the Workplace (Health, Safety and Welfare) Regulations 1992 requires windows and transparent surfaces in walls, partitions, doors and gates to be of safety material or protected against breakage where health or safety makes that necessary, and to be marked so people notice them. The employer or the person in control of the premises decides what is needed through their risk assessment.

Fire-rated glass is different

Glass in fire doors, fire screens and protected escape routes has to be fire-rated glass tested as part of that door or screen system, under Approved Document B and the fire safety duties of the building's responsible person. Laminated and security glass are not fire-rated unless the product says so. Where a pane needs both fire and security performance, it must be a product tested for both.

How it works

Send sizes or use the quote tool
Free survey at your Ashford, Surrey address
Fixed price in writing
Glass made, then fitted

Toughened safety glass in Ashford, Surrey: questions

Can you survey in Ashford, Surrey and nearby towns?

Yes. Surveys in Ashford, Surrey, Staines-upon-Thames and Feltham are booked around installer availability.

How can I tell if glass is toughened?

Look for a permanent mark etched in a corner naming the standard. Polarised sunglasses can also show faint patterns in toughened glass. We can check during the survey.

Can toughened glass be cut to fit?

No. Cutting or drilling toughened glass makes it shatter, so every pane, hole and notch is made to size before toughening.

Is toughened glass a security glass?

No. Toughened glass is strong and breaks safely, but once broken the pane falls out and leaves the opening clear. For security, choose laminated glass or a unit with a laminated pane.

Toughened safety glass in nearby towns

Other glazing in Ashford, Surrey

Ready for a price? Use the form or call 0800 088 6248.